Chapter 1. INTRODUCTION
Figure 1-1. Communications terminal, satellite AN/TSC-86.
Consolidated Index of Army Publications and Blank Forms
Table 1-1. System Performance
Table 1-2. Equipment Complement
Section III. FUNCTIONAL DESCRIPTION
Figure 1-2. System Functional Block Diagram AN/TSC-86 Terminal.
Detailed Terminal System Description.
Figure 1-3. Radio Subsystem Block Diagram.
Detailed Terminal System Description. (Cont)
Figure 1-4. Receiver Section Block Diagram.
Receive Section.
Equipment Location
Figure 1-5. Equipment Location, Roadside of Shelter.
Figure 1-6.
Chapter 2. SERVICE UPON RECEIPT AND INSTALLATION
Section II. SITE AND SHELTER REQUIREMENTS
Locating the Sighting Points
Figure 2-2. Sighting and Typical Placement of 8-foot Antenna and Equipment.
Placement of Terminal and Power Pallet
Figure 2-3. Pocket Transit.
Using the Pocket Transit
Unpacking of Stowed Items
Figure 2-4. Location of Stowed Items (Sheet 1 of 3).
Figure 2-4. Location of Stowed Items (Sheet 2 of 3).
Figure 2-4. Location of Stowed Items (Sheet 3 of 3).
Figure 2-5. Antenna center Section and Carriage Assembly, Unstowing and Lifting Items (Sheet 1 of 2).
Table 2-1. List of Stowed Items
Figure 2-5. Antenna Center Section and Carriage Assembly, Unstowing and Lifting Items (Sheet 2 of 2).
Assembling the Antenna
Figure 2-6. Placement of Antenna Ground Pads.
Figure 2-7. Assembled Antenna Support Structure, Plan View. - TM-11-5895-846-140041
Figure 2-7. Assembled Antenna Support Structure, Plan View. - TM-11-5895-846-140042
Figure 2-8. Assembled Antenna. Left Side View.
Figure 2-9. Assembled Antenna, Rear View.
Installation of Reflector Quarter Sections and Feed Tube Assembly
Installation of Messenger Pole and Cable
Figure 2-10. Antenna and Power Cable Connections and Entry Panels (Sheet 1 of 2)
Figure 2-10. Antenna and Power Cable Connections and Entry Panels (Sheet 2 of 2)
Final Alinement and Adjustment.
Installing Ground and Power Cables
Installing the Radiation Hazard Fence
Figure 2-12. Installation of Hazard Area Fence.
Figure 2-13. Hazard area Fence Posts, Rope and Warning Signs; Assembly Details.
Figure 2-14. Placement of anchors.
Figure 2-15. Tie-Down Cable and Take-Up Device (Sheet 1 of 2).
Figure 2-15. Tie-Down Cable and Take-Up Device (Sheet 2 of 2).
Section V. PRELIMINARY ADJUST OF EQUIPMENT
Adjusting the Shelter Vents
Figure 2-16. Multiplexer Set Module/Group Configuration.
Section VI. INSTALLATION AND CIRCUIT LINEUP
Figure 2-17. External Circuit Connection Entry Panels (Sheet 1 of 2)
Figure 2-17. External Circuit Connection Entry Panels (Sheet 2 of 2)
Shelter Interior Patch Panel Connections
Shelter Interior Patch Panel Connections (Cont)
Figure 2-20. IF Patch Panel, Patch Connector Locations.
Figure 2-21. Transmit Patch Panel, Patch Connector Locations.
Central Distribution Frame.
VF Patch Panel
Chapter 3. OPERATING INSTRUCTIONS
Figure 3-1. Power Distribution Panel, Controls and Indicators.
Figure 3-2. Track Patch Panel, Controls and Indicators.
Figure 3-3. Downconverter, Controls and Indicators.
Figure 3-4. Antenna Control, Controls and Indicators.
Figure 3-5. Amplifier/Mixer, Controls and Indicators.
Figure 3-6. Upconverter, Controls and Indicators.
Figure 3-7. Waveguide Switch w/Air Vent, Controls.
Figure 3-8. Power Amplifier, Controls and Indicators
Figure 3-9. Power Supply PP-7087, Controls and Indicators.
Figure 3-10. Alarm Monitor, Controls and Indicators (Sheet 1 of 2).
Figure 3-10. Alarm Monitor, Controls and Indicators (Sheet 2 of 2).
Figure 3-11. Control/Translator, Controls and Indicators.
Figure 3-12. AC Regulator Monitor Panel, Controls and Indicators.
Figure 3-13. TTY/Low Level Patch Panel, Controls and Indicators.
Figure 3-14. TTY Loop Monitor, Control and Indicators
Figure 3-15. VF Patch Panel, Controls and Indicators.
Figure 3-16. Remote Control, Controls and Indicators.
Table 3-1. Power Distribution Panel, Operator's Control and Indicators
Table 3-3. Downconverter, Operator's Control and Indicators
Table 3-5. Amplifier/Mixer, Operator's Control and Indicators
Table 3-8. Power Amplifier, Operator's Controls and Indicators
Table 3-10. Alarm Monitor, Operator's Control and Indicators
Table 3-11 LNA Control/Translator, Operator's Control and Indicators
Table 3-14. TTY Loop Monitor, Operator's Control and Indicators
Section II. OPERATION UNDER USUAL CONDITIONS
Turn-On of External Power
Power Distribution Panel.
Rack 4, Alarm Monitor (A19) and LNA Control/ Translator (A20).
Alarm Monitor Safety Alert Check
Figure 3-17. Klystron Frequency Chart and tuning Cavities.
Tuning the Receiver
Receive Field Alinement.
Figure 3-18. Low Noise Amplifier, Gain/Slope Adjustment Diagram.
Receive Field Alinement. (cont)
Table 3-18. LNA Response Adjustment
Table 3-18. LNA Response Adjustment (Cont)
Figure 3-20. LNA Gain/Slope Level.
Figure 3-21. Overall Receiver Gain Adjustment Diagram.
Performing the Transmit-Receive System Loop Test
Acquiring the Satellite
Setting the Antenna Elevation Safety Switch for the 8-foot antenna
Section III.OPERATION UNDER UNUSUAL CONDITIONS
Failure of On-Line Transmitter Group
Section IV. PREPARATION FOR MOVEMENT
Removal of Antenna Anchor Cables
Stowage of Items in the Shelter
Final Preparation for Movement.
Figure 3-23. Preparation for Transport by Rail.
Transport by Air
Figure 3-24. Shelter, Sling Assembly and Typical Air Lift Configuration (Sheet 2 of 2)
Transport by Air (Cont)
Chapter 4. OPERATORICREW MAINTENANCE INSTRUCTIONS
Table 4-1. Operator/Crew Preventative Maintenance Checks and Services
Section IV. MAINTENANCE OF ANTENNA AS-3036/TSC
Section V. MAINTENANCE OF ANCILLARY EQUIPMENT
Chapter 5. ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
Section III. LUBRICATION INSTRUCTIONS
Section IV. PREVENTIVE MAINTENANCE CHECKS AND SERVICES
RSS System Troubleshooting Chart
Section VI. MAINTENANCE OF ANTENNA CONTROL C-10273 AND REMOTE CONTROL UNIT
Testing and Fault Isolation - TM-11-5895-846-140130
Table 5-4. Monitor Meter Normal Indications
Removal and Replacement of Modules
Section VII. MAINTENANCE OF RADIO FREQUENCY AMPLIFIER AM-6703/TSC AND POWER SUPPLY PP-7087/TSC
Testing and Fault Isolation - TM-11-5895-846-140134
Table 5-8. Power Amplifier Monitor Meter Indications
TEMP-KLYSTRON Fault and HV INHIBIT Status Indicators.
BODY OVLD Fault and HV INHIBIT Status Indicators.
HV INHIBIT Status Indicator and HV MAIN Fuse Indicator.
On-line transmitter group
Removal and Replacement of Power Amplifier Module
Figure 5-3. Power Amplifier, Top Access Opening. Removal Items.
Removal and Replacement of RF Low Power Alarm Module A1.
Removal and Replacement of RF Monitor Module A2.
Figure 5-5. Power Amplifier, Module A2 Captive Screws and Right-Side Access Opening, Removal Items.
Removal of Power Amplifier Blower B1.
Figure 5-7. Power Amplifier, Front Access Opening, Removal Items.
Replacement of Power Amplifier Blower B1.
Figure 5-8. Power Amplifier, Bottom Access Opening, Removal Items.
Replacement of Klystron V1.
Removal and Replacement of Power Amplifier
Figure 5-9. Power Amplifier, Rear Panel.
Removal and Replacement of Power Supply Moduels
Figure 5-11. Power Supply Bottom View, Component Locations.
Removal and Replacement of Control and Overload Module A1
Removal and Replacement of High Voltage Transformer/Rectifier Modules A14, A15, A16 and A17
Removal and Replacement of Power Supply
Figure 5-12. Power supply, rear panel.
Section VIII. MAINTENANCE OF ELECTRONIC FREQUENCY CONVERTER CV-3199/TSC
Figure 5-13. Upconverter Adjustment Controls.
Figure 5-14. Upconverter Module Locations.
Upconverter with 700 MHz Modem.
Figure 5-15. Frequency Synthesizer Module, Submodule Locations.
Upconverter Gain Adjustments
System Using Only 70 MHz Modem.
Removal and Replacement of Upconverter Modules
Removal and Replacement of SHF Filter/Detector Module A5
Removal and Replacement of Main Loop Module
Removal and Replacement of Upconverter
Figure 5-16. Upconverter Rear Panel
Section IX. MAINTENANCE OF ELECTRONIC FREQUENCY CONVERTER CV-3200/TSC
Downconverter, Receiver Gain Adjustment
Figure 5-17. Downconverter, Receiver Gain Adjustment Diagram.
Figure 5-18. Downconverter, Adjustment Controls and Module Locations.
Table 5-10. Accessory Items Required for Downconverter Receiver Gain Adjustment
Removal and Replacement of Downconverter Modules
Removal and Replacement of Submodules on the Frequency Synthesizer Module.
Figure 5-19. Downconverter, Rear Panel.
Section X. MAINTENANCE OF AMPLIFIER/MIXER AM-6704/TSC
Troubleshooting the Amplifier/Mixer.
Amplifier/Mixer Adjustments
Figure 5-20. Amplifier/Mixer Module and Rear Panel Connectors Location.
Adjustments to Perform when SHF Drive Assembly A2 is Replaced.
Figure 5-21. Amplifier/Mixer Module and Rear Panel Connectors Location.
Removal and Replacement of SHF Drive Assembly A2
Section XI. MAINTENANCE OF LNA CONTROL/TRANSLATOR
Figure 5-22. LNA Control/Translator, Module Location.
Figure 5-23. LNA Control/Translator, Rear Panel.
Power Supply Tests.
Removal and Replacement of LNA Control/Translator Modules
Section XII. MAINTENANCE OF ALARM MONITOR BZ-236/TSC
Figure 5-24. Alarm Monitor, Module Locations.
Section XIII. MAINTENANCE OF ANTENNA AS-3036/TSC
Figure 5-26. Antenna, Location of Components.
Removal of the Cross-Elevation Actuator
Figure 5-27. Antenna Actuator, Disassembly View Showing the Motor-Brake-Tachometer.
Section XIV. MAINTENANCE OF PARAMETRIC AMPLIFIER AM-6700/TSC
Preliminary Checks.
Section XV. MAINTENANCE OF LNA BITE
Figure 5-28. LNA BITE, Adjustment Items.
Section XVI. MAINTENANCE OF WAVEGUIDE SWITCH
Removal and Replacement of IF Patch Panel.
Removal and Replacement of Multiplexer A13
Removal and Replacement of the TTY Loop Monitor, Al 7.
Removal and Replacement of the Line Conditioning. Unit No. 2, A26.
Removal and Replacement of the Central Distribution Frame (CDF), A30.
Removal and Replacement of the 20 Hz Ringing Generator, A36.
Chapter 6. FUNCTIONING OF EQUIPMENT
Figure 6-1. AN/TSC-86 Satellite Communications Terminal Deployed Less Transporters.
Figure 6-2. AN/TSC-86 Satellite Terminal Ground Transport Mode..
Terminal.
Figure 6-3. Shelter, Plan View of Entry Panels and cooling Parts.
Figure 6-4. AN/TSC-86 Shelter Rack Elevation (Sheet 1 of 2).
Figure 6-4. AN/TSC-86 Shelter Rack Elevation (Sheet 2 of 2).
Terminal/User Interface
Figure 6-5. Antenna Mounted Electronics
Received signal distribution.
Commmunications Subsystem
Figure 6-6. CDF Reconfiguration Matrix, Function Diagram.
Figure 6-7. CDF Program Pin Crosspoint Switch Function
Teletype, TTY/low level patch panel.
Figure 6-8. Communications Subsystem IF Patch Panel Appearances.
Section III. ELECTRONIC FUNCTIONAL DESCRIPTION
Figure 6-9. Receive Chain Block Diagram.
Signal Flow, RF Subsystem
Figure 6-10. Transmit Chain Block Diagram.
Signal Flow, Communications Subsystem
Figure 6-11. Voice Frequency Circuits, Block Diagram.
Teletype Circuits.
Figure 6-12. Teletype Circuits, Block Diagram.
Data Circuits
Figure 6-13. Data and Auxiliary IF Circuits, Block Diagram.
Unit Functions
Figure 6-15. Basic Antenna Operation.
Low Noise Amplifier
Figure 6-16. LNA Block Diagram.
LNA Control/Translator
Figure 6-17. Test Translator Block Diagram.
Control, fault detection and isolation
Figure 6-18. LNA Testing Block Diagram.
Downconverter
Figure 6-19. Downconverter Block Diagram.
Upconverter.
Figure 6-20. Upconverter Block Diagram.
Power Amplifiers.
Figure 6-21. RF Amplifier Block Diagram.
High Voltage Power Supply
Figure 6-22. HVP Block Diagram.
Amplifier/Mixer
Figure 6-23. Amplifier-Mixer Simplified Block Diagram.
Unit Functions, Communications Subsystem
Section IV. AUXILIARY FUNCTIONS
Power Distribution
Chapter 7. DIRECT SUPPORT MAINTENANCE INSTRUCTIONS
Figure 7-1. Power Distribution Panel, Component Parts Location.
Troubleshooting the Wired Shelter
Removal, and Replacement of Power Distribution Panel Components.
Maintenance of Power Entry Panel and EMI Filter
Section IV. MAINTENANCE OF POWER PALLET
Figure 7-2. Power Pallet, Component Parts Location
Removal and Replacement of Power Switch Box
Connectors J1, J2, J3 and J4.
Chapter 8. GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
Receiver Gain
Figure 8-1. Overall Receiver Gain Field Calibration.
Frequency Accuracy
Figure 8-2. Synthesizer Reference Oscillator Test Setup.
Figure 8-3. Frequency Accuracy Test Setup.
SHF Transmit Frequency.
Figure 8-4. -Transmitter Power Output Test Setup.
Section IV. TROUBLESHOOTING OF ALARM MONITOR
Table 8-4. Test Fixture, Alarm Monitor Fault/Safety Gate, Parts List
Table 8-5. Universal Power Cable, Parts List
Table 8-6. Universal Power Cable, Wiring Chart
Figure 8-5. Universal Power Cable Assembly.
Alarm Monitor Power Supply Troubleshooting.
Table 8-7. Federal Supply Code for Manufacturers (FSCM), Code-to-Name Sequence
Figure 8-6. Alarm Monitor Power Supply, Test Setup.
Figure 8-7. Alarm Monitor Power Supply, Adjustment Locations.
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart (cont) - TM-11-5895-846-140280
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart (cont) - TM-11-5895-846-140281
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart (cont) - TM-11-5895-846-140282
Alarm Monitor Power Supply Disassembly
Figure 8-8. Alarm Monitor Power Supply Support Fixtures Fabrication Details (Sheet 1 of 2).
Figure 8-8. Alarm Monitor Power Supply Support Fixtures Fabrication Details (Sheet 2 of 2).
Figure 8-9. Alarm Monitor Power Supply, Disassembly Details.
Figure 8-10. Alarm Monitor Power Supply, Disassembled View Showing Typical Use of Support Fixtures (Sheet 1 of 2).
Figure 8-10. Alarm Monitor Power Supply, Disassembled View Showing Typical Use of Support Fixtures (Sheet 2 of 2).
Alarm Monitor Power Supply, Component Replacement
Figure 8-11. Alarm Monitor Fault/Safety Gate, Test Setup.
Table 8-9. Alarm Monitor Fault/Safety Gate, Troubleshooting Chart
Table 8-10. Alarm Monitor Fault/Safety Test Fixture, Switch Positions
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart - Continued - TM-11-5895-846-140294
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart - Continued - TM-11-5895-846-140295
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart - Continued - TM-11-5895-846-140296
Alarm Monitor Troubleshooting
Table 8-13. Alarm Monitor, Troubleshooting Chart
Table 8-13. Alarm Monitor, Troubleshooting Chart (Cont) - TM-11-5895-846-140299
Table 8-13. Alarm Monitor, Troubleshooting Chart (Cont) - TM-11-5895-846-140300
Table 8-13. Alarm Monitor, Troubleshooting Chart (Cont) - TM-11-5895-846-140301
Appendix A: REFERENCES
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140303
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140304
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140305
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140306
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140307
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140308
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140309
Appendix B: MAINTENANCE ALLOCATION
Tool or Test Equipment Requirements
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140313
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140314
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140315
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140316
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140317
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140318
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140319
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140320
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140321
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140322
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140323
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140324
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140325
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140326
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140327
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140329
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140330
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140331
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140332
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140333
SECTION IV. REMARKS
Appendix C: RECEIVE FIELD ALIGNMENT (AS-3199)
Figure C-1. Low Noise Amplifier, Gain/Slope Adjustment Diagram.
Low Noise Gain/Slope Adjustment
Table C-1 LNA Response Adjustment
Figure C-2. LNA Adjustment Locations
Overall Receiver Gain.
Figure C-4. LNA, Overall Receiver Gain Calibration Diagram.
Overall Receiver Gain. (cont)
Appendix D: STRAPPING REQUIREMENTS FOR COMMUNICATIONS SUBSYSTEM
INDEX
INDEX (Cont) - TM-11-5895-846-140345
INDEX (Cont) - TM-11-5895-846-140346
INDEX (Cont) - TM-11-5895-846-140347
INDEX (Cont) - TM-11-5895-846-140348
INDEX (Cont) - TM-11-5895-846-140349
Figure FO-1. RSS System Fault, Troubleshooting Chart.
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 1 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 2 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 3 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 4 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 5 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 6 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 7 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 8 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 9 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 10 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 11 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 12 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 13 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 14 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 15 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 16 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 17 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 18 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 19 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 20 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 21 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 22 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 23 of 23)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 1 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 2 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 3 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 4 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 5 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 6 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 7 of 7)
Figure FO-4. AN/TSC-86, Functional Block Diagram
Figure FO-5. Power Pallet, Schematic Wiring Diagram
Figure FO-6. Power Distribution Panel, Schematic Wiring Diagram (Sheet 1 of 2)
Figure FO-6. Power Distribution Panel, Schematic Wiring Diagram (Sheet 2 of 2)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 1 of 4)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 2 of 4)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 3 of 4)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 4 of 4)
Figure FO-8. EMI Filter, Schematic Wiring Diagram
Figure FO-9. Alarm Monitor Power Supply Test Fixture, Schematic Diagram
Figure FO-10. Alarm Monitor Power Supply Test Fixture Top Chassis Layout.
Figure FO-11. Alarm Monitor Power Supply Test Fixture, Bottom Chassis Layout.
Figure FO-12. Alarm monitor Supply Test Fixture, Top Chassis Marking.
Figure FO-13. Alarm Monitor power Supply Test Fixture, Bottom Chassis Markings.
Figure FO-14. Alarm Monitor Power Supply Test Fixture, Hinge Assembly.
Figure FO-15. Alarm Monitor Fault/Safety Gate Test Fixture, Schematic Diagram
Figure FO-16. Alarm Monitor Fault/Safety Gate Test Fixture, Chassis Layout
Figure FO-17. Alarm Monitor Fault/Safety Gate Test Fixture Chassis Markings
Figure FO-18. Alarm Monitor Power Supply, Schematic Diagram.
Figure FO-19. Alarm Monitor Fault/Safety Gate, Logic Diagram (Sheet 1of 3).
Figure FO-19. Alarm Monitor Fault/Safety Gate, Logic Diagram (Sheet 2 of 3).
Figure FO-19. Alarm Monitor Fault/Safety Gate, Logic Diagram (Sheet 3 of 3).
Figure FO-20. Alarm Monitor, Schematic Wiring Diagram
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 1 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 2 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 3 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 4 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 5 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 6 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 7 of 12).
oFigure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 8 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 9 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 10 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 11 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 12 of 12).
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 1 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 2 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 3 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 4 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 5 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 6 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 7 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 8 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 9 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 10 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 11 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 12 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 13 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 14 of 14)
TM-11-5895-846-14 Satelite Communications Terminnal AN/TSC-86 (NSN 5895-01-083-6891) Manual
Figure 1-1. Communications terminal, satellite AN/TSC-86.
Consolidated Index of Army Publications and Blank Forms
Table 1-1. System Performance
Table 1-2. Equipment Complement
Section III. FUNCTIONAL DESCRIPTION
Figure 1-2. System Functional Block Diagram AN/TSC-86 Terminal.
Detailed Terminal System Description.
Figure 1-3. Radio Subsystem Block Diagram.
Detailed Terminal System Description. (Cont)
Figure 1-4. Receiver Section Block Diagram.
Receive Section.
Equipment Location
Figure 1-5. Equipment Location, Roadside of Shelter.
Figure 1-6.
Chapter 2. SERVICE UPON RECEIPT AND INSTALLATION
Section II. SITE AND SHELTER REQUIREMENTS
Locating the Sighting Points
Figure 2-2. Sighting and Typical Placement of 8-foot Antenna and Equipment.
Placement of Terminal and Power Pallet
Figure 2-3. Pocket Transit.
Using the Pocket Transit
Unpacking of Stowed Items
Figure 2-4. Location of Stowed Items (Sheet 1 of 3).
Figure 2-4. Location of Stowed Items (Sheet 2 of 3).
Figure 2-4. Location of Stowed Items (Sheet 3 of 3).
Figure 2-5. Antenna center Section and Carriage Assembly, Unstowing and Lifting Items (Sheet 1 of 2).
Table 2-1. List of Stowed Items
Figure 2-5. Antenna Center Section and Carriage Assembly, Unstowing and Lifting Items (Sheet 2 of 2).
Assembling the Antenna
Figure 2-6. Placement of Antenna Ground Pads.
Figure 2-7. Assembled Antenna Support Structure, Plan View. - TM-11-5895-846-140041
Figure 2-7. Assembled Antenna Support Structure, Plan View. - TM-11-5895-846-140042
Figure 2-8. Assembled Antenna. Left Side View.
Figure 2-9. Assembled Antenna, Rear View.
Installation of Reflector Quarter Sections and Feed Tube Assembly
Installation of Messenger Pole and Cable
Figure 2-10. Antenna and Power Cable Connections and Entry Panels (Sheet 1 of 2)
Figure 2-10. Antenna and Power Cable Connections and Entry Panels (Sheet 2 of 2)
Final Alinement and Adjustment.
Installing Ground and Power Cables
Installing the Radiation Hazard Fence
Figure 2-12. Installation of Hazard Area Fence.
Figure 2-13. Hazard area Fence Posts, Rope and Warning Signs; Assembly Details.
Figure 2-14. Placement of anchors.
Figure 2-15. Tie-Down Cable and Take-Up Device (Sheet 1 of 2).
Figure 2-15. Tie-Down Cable and Take-Up Device (Sheet 2 of 2).
Section V. PRELIMINARY ADJUST OF EQUIPMENT
Adjusting the Shelter Vents
Figure 2-16. Multiplexer Set Module/Group Configuration.
Section VI. INSTALLATION AND CIRCUIT LINEUP
Figure 2-17. External Circuit Connection Entry Panels (Sheet 1 of 2)
Figure 2-17. External Circuit Connection Entry Panels (Sheet 2 of 2)
Shelter Interior Patch Panel Connections
Shelter Interior Patch Panel Connections (Cont)
Figure 2-20. IF Patch Panel, Patch Connector Locations.
Figure 2-21. Transmit Patch Panel, Patch Connector Locations.
Central Distribution Frame.
VF Patch Panel
Chapter 3. OPERATING INSTRUCTIONS
Figure 3-1. Power Distribution Panel, Controls and Indicators.
Figure 3-2. Track Patch Panel, Controls and Indicators.
Figure 3-3. Downconverter, Controls and Indicators.
Figure 3-4. Antenna Control, Controls and Indicators.
Figure 3-5. Amplifier/Mixer, Controls and Indicators.
Figure 3-6. Upconverter, Controls and Indicators.
Figure 3-7. Waveguide Switch w/Air Vent, Controls.
Figure 3-8. Power Amplifier, Controls and Indicators
Figure 3-9. Power Supply PP-7087, Controls and Indicators.
Figure 3-10. Alarm Monitor, Controls and Indicators (Sheet 1 of 2).
Figure 3-10. Alarm Monitor, Controls and Indicators (Sheet 2 of 2).
Figure 3-11. Control/Translator, Controls and Indicators.
Figure 3-12. AC Regulator Monitor Panel, Controls and Indicators.
Figure 3-13. TTY/Low Level Patch Panel, Controls and Indicators.
Figure 3-14. TTY Loop Monitor, Control and Indicators
Figure 3-15. VF Patch Panel, Controls and Indicators.
Figure 3-16. Remote Control, Controls and Indicators.
Table 3-1. Power Distribution Panel, Operator's Control and Indicators
Table 3-3. Downconverter, Operator's Control and Indicators
Table 3-5. Amplifier/Mixer, Operator's Control and Indicators
Table 3-8. Power Amplifier, Operator's Controls and Indicators
Table 3-10. Alarm Monitor, Operator's Control and Indicators
Table 3-11 LNA Control/Translator, Operator's Control and Indicators
Table 3-14. TTY Loop Monitor, Operator's Control and Indicators
Section II. OPERATION UNDER USUAL CONDITIONS
Turn-On of External Power
Power Distribution Panel.
Rack 4, Alarm Monitor (A19) and LNA Control/ Translator (A20).
Alarm Monitor Safety Alert Check
Figure 3-17. Klystron Frequency Chart and tuning Cavities.
Tuning the Receiver
Receive Field Alinement.
Figure 3-18. Low Noise Amplifier, Gain/Slope Adjustment Diagram.
Receive Field Alinement. (cont)
Table 3-18. LNA Response Adjustment
Table 3-18. LNA Response Adjustment (Cont)
Figure 3-20. LNA Gain/Slope Level.
Figure 3-21. Overall Receiver Gain Adjustment Diagram.
Performing the Transmit-Receive System Loop Test
Acquiring the Satellite
Setting the Antenna Elevation Safety Switch for the 8-foot antenna
Section III.OPERATION UNDER UNUSUAL CONDITIONS
Failure of On-Line Transmitter Group
Section IV. PREPARATION FOR MOVEMENT
Removal of Antenna Anchor Cables
Stowage of Items in the Shelter
Final Preparation for Movement.
Figure 3-23. Preparation for Transport by Rail.
Transport by Air
Figure 3-24. Shelter, Sling Assembly and Typical Air Lift Configuration (Sheet 2 of 2)
Transport by Air (Cont)
Chapter 4. OPERATORICREW MAINTENANCE INSTRUCTIONS
Table 4-1. Operator/Crew Preventative Maintenance Checks and Services
Section IV. MAINTENANCE OF ANTENNA AS-3036/TSC
Section V. MAINTENANCE OF ANCILLARY EQUIPMENT
Chapter 5. ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
Section III. LUBRICATION INSTRUCTIONS
Section IV. PREVENTIVE MAINTENANCE CHECKS AND SERVICES
RSS System Troubleshooting Chart
Section VI. MAINTENANCE OF ANTENNA CONTROL C-10273 AND REMOTE CONTROL UNIT
Testing and Fault Isolation - TM-11-5895-846-140130
Table 5-4. Monitor Meter Normal Indications
Removal and Replacement of Modules
Section VII. MAINTENANCE OF RADIO FREQUENCY AMPLIFIER AM-6703/TSC AND POWER SUPPLY PP-7087/TSC
Testing and Fault Isolation - TM-11-5895-846-140134
Table 5-8. Power Amplifier Monitor Meter Indications
TEMP-KLYSTRON Fault and HV INHIBIT Status Indicators.
BODY OVLD Fault and HV INHIBIT Status Indicators.
HV INHIBIT Status Indicator and HV MAIN Fuse Indicator.
On-line transmitter group
Removal and Replacement of Power Amplifier Module
Figure 5-3. Power Amplifier, Top Access Opening. Removal Items.
Removal and Replacement of RF Low Power Alarm Module A1.
Removal and Replacement of RF Monitor Module A2.
Figure 5-5. Power Amplifier, Module A2 Captive Screws and Right-Side Access Opening, Removal Items.
Removal of Power Amplifier Blower B1.
Figure 5-7. Power Amplifier, Front Access Opening, Removal Items.
Replacement of Power Amplifier Blower B1.
Figure 5-8. Power Amplifier, Bottom Access Opening, Removal Items.
Replacement of Klystron V1.
Removal and Replacement of Power Amplifier
Figure 5-9. Power Amplifier, Rear Panel.
Removal and Replacement of Power Supply Moduels
Figure 5-11. Power Supply Bottom View, Component Locations.
Removal and Replacement of Control and Overload Module A1
Removal and Replacement of High Voltage Transformer/Rectifier Modules A14, A15, A16 and A17
Removal and Replacement of Power Supply
Figure 5-12. Power supply, rear panel.
Section VIII. MAINTENANCE OF ELECTRONIC FREQUENCY CONVERTER CV-3199/TSC
Figure 5-13. Upconverter Adjustment Controls.
Figure 5-14. Upconverter Module Locations.
Upconverter with 700 MHz Modem.
Figure 5-15. Frequency Synthesizer Module, Submodule Locations.
Upconverter Gain Adjustments
System Using Only 70 MHz Modem.
Removal and Replacement of Upconverter Modules
Removal and Replacement of SHF Filter/Detector Module A5
Removal and Replacement of Main Loop Module
Removal and Replacement of Upconverter
Figure 5-16. Upconverter Rear Panel
Section IX. MAINTENANCE OF ELECTRONIC FREQUENCY CONVERTER CV-3200/TSC
Downconverter, Receiver Gain Adjustment
Figure 5-17. Downconverter, Receiver Gain Adjustment Diagram.
Figure 5-18. Downconverter, Adjustment Controls and Module Locations.
Table 5-10. Accessory Items Required for Downconverter Receiver Gain Adjustment
Removal and Replacement of Downconverter Modules
Removal and Replacement of Submodules on the Frequency Synthesizer Module.
Figure 5-19. Downconverter, Rear Panel.
Section X. MAINTENANCE OF AMPLIFIER/MIXER AM-6704/TSC
Troubleshooting the Amplifier/Mixer.
Amplifier/Mixer Adjustments
Figure 5-20. Amplifier/Mixer Module and Rear Panel Connectors Location.
Adjustments to Perform when SHF Drive Assembly A2 is Replaced.
Figure 5-21. Amplifier/Mixer Module and Rear Panel Connectors Location.
Removal and Replacement of SHF Drive Assembly A2
Section XI. MAINTENANCE OF LNA CONTROL/TRANSLATOR
Figure 5-22. LNA Control/Translator, Module Location.
Figure 5-23. LNA Control/Translator, Rear Panel.
Power Supply Tests.
Removal and Replacement of LNA Control/Translator Modules
Section XII. MAINTENANCE OF ALARM MONITOR BZ-236/TSC
Figure 5-24. Alarm Monitor, Module Locations.
Section XIII. MAINTENANCE OF ANTENNA AS-3036/TSC
Figure 5-26. Antenna, Location of Components.
Removal of the Cross-Elevation Actuator
Figure 5-27. Antenna Actuator, Disassembly View Showing the Motor-Brake-Tachometer.
Section XIV. MAINTENANCE OF PARAMETRIC AMPLIFIER AM-6700/TSC
Preliminary Checks.
Section XV. MAINTENANCE OF LNA BITE
Figure 5-28. LNA BITE, Adjustment Items.
Section XVI. MAINTENANCE OF WAVEGUIDE SWITCH
Removal and Replacement of IF Patch Panel.
Removal and Replacement of Multiplexer A13
Removal and Replacement of the TTY Loop Monitor, Al 7.
Removal and Replacement of the Line Conditioning. Unit No. 2, A26.
Removal and Replacement of the Central Distribution Frame (CDF), A30.
Removal and Replacement of the 20 Hz Ringing Generator, A36.
Chapter 6. FUNCTIONING OF EQUIPMENT
Figure 6-1. AN/TSC-86 Satellite Communications Terminal Deployed Less Transporters.
Figure 6-2. AN/TSC-86 Satellite Terminal Ground Transport Mode..
Terminal.
Figure 6-3. Shelter, Plan View of Entry Panels and cooling Parts.
Figure 6-4. AN/TSC-86 Shelter Rack Elevation (Sheet 1 of 2).
Figure 6-4. AN/TSC-86 Shelter Rack Elevation (Sheet 2 of 2).
Terminal/User Interface
Figure 6-5. Antenna Mounted Electronics
Received signal distribution.
Commmunications Subsystem
Figure 6-6. CDF Reconfiguration Matrix, Function Diagram.
Figure 6-7. CDF Program Pin Crosspoint Switch Function
Teletype, TTY/low level patch panel.
Figure 6-8. Communications Subsystem IF Patch Panel Appearances.
Section III. ELECTRONIC FUNCTIONAL DESCRIPTION
Figure 6-9. Receive Chain Block Diagram.
Signal Flow, RF Subsystem
Figure 6-10. Transmit Chain Block Diagram.
Signal Flow, Communications Subsystem
Figure 6-11. Voice Frequency Circuits, Block Diagram.
Teletype Circuits.
Figure 6-12. Teletype Circuits, Block Diagram.
Data Circuits
Figure 6-13. Data and Auxiliary IF Circuits, Block Diagram.
Unit Functions
Figure 6-15. Basic Antenna Operation.
Low Noise Amplifier
Figure 6-16. LNA Block Diagram.
LNA Control/Translator
Figure 6-17. Test Translator Block Diagram.
Control, fault detection and isolation
Figure 6-18. LNA Testing Block Diagram.
Downconverter
Figure 6-19. Downconverter Block Diagram.
Upconverter.
Figure 6-20. Upconverter Block Diagram.
Power Amplifiers.
Figure 6-21. RF Amplifier Block Diagram.
High Voltage Power Supply
Figure 6-22. HVP Block Diagram.
Amplifier/Mixer
Figure 6-23. Amplifier-Mixer Simplified Block Diagram.
Unit Functions, Communications Subsystem
Section IV. AUXILIARY FUNCTIONS
Power Distribution
Chapter 7. DIRECT SUPPORT MAINTENANCE INSTRUCTIONS
Figure 7-1. Power Distribution Panel, Component Parts Location.
Troubleshooting the Wired Shelter
Removal, and Replacement of Power Distribution Panel Components.
Maintenance of Power Entry Panel and EMI Filter
Section IV. MAINTENANCE OF POWER PALLET
Figure 7-2. Power Pallet, Component Parts Location
Removal and Replacement of Power Switch Box
Connectors J1, J2, J3 and J4.
Chapter 8. GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
Receiver Gain
Figure 8-1. Overall Receiver Gain Field Calibration.
Frequency Accuracy
Figure 8-2. Synthesizer Reference Oscillator Test Setup.
Figure 8-3. Frequency Accuracy Test Setup.
SHF Transmit Frequency.
Figure 8-4. -Transmitter Power Output Test Setup.
Section IV. TROUBLESHOOTING OF ALARM MONITOR
Table 8-4. Test Fixture, Alarm Monitor Fault/Safety Gate, Parts List
Table 8-5. Universal Power Cable, Parts List
Table 8-6. Universal Power Cable, Wiring Chart
Figure 8-5. Universal Power Cable Assembly.
Alarm Monitor Power Supply Troubleshooting.
Table 8-7. Federal Supply Code for Manufacturers (FSCM), Code-to-Name Sequence
Figure 8-6. Alarm Monitor Power Supply, Test Setup.
Figure 8-7. Alarm Monitor Power Supply, Adjustment Locations.
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart (cont) - TM-11-5895-846-140280
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart (cont) - TM-11-5895-846-140281
Table 8-8. Alarm Monitor Power Supply, Troubleshooting Chart (cont) - TM-11-5895-846-140282
Alarm Monitor Power Supply Disassembly
Figure 8-8. Alarm Monitor Power Supply Support Fixtures Fabrication Details (Sheet 1 of 2).
Figure 8-8. Alarm Monitor Power Supply Support Fixtures Fabrication Details (Sheet 2 of 2).
Figure 8-9. Alarm Monitor Power Supply, Disassembly Details.
Figure 8-10. Alarm Monitor Power Supply, Disassembled View Showing Typical Use of Support Fixtures (Sheet 1 of 2).
Figure 8-10. Alarm Monitor Power Supply, Disassembled View Showing Typical Use of Support Fixtures (Sheet 2 of 2).
Alarm Monitor Power Supply, Component Replacement
Figure 8-11. Alarm Monitor Fault/Safety Gate, Test Setup.
Table 8-9. Alarm Monitor Fault/Safety Gate, Troubleshooting Chart
Table 8-10. Alarm Monitor Fault/Safety Test Fixture, Switch Positions
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart - Continued - TM-11-5895-846-140294
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart - Continued - TM-11-5895-846-140295
Table 8-12. Alarm Monitor Fault/Safety Gate Component Fault Isolation Chart - Continued - TM-11-5895-846-140296
Alarm Monitor Troubleshooting
Table 8-13. Alarm Monitor, Troubleshooting Chart
Table 8-13. Alarm Monitor, Troubleshooting Chart (Cont) - TM-11-5895-846-140299
Table 8-13. Alarm Monitor, Troubleshooting Chart (Cont) - TM-11-5895-846-140300
Table 8-13. Alarm Monitor, Troubleshooting Chart (Cont) - TM-11-5895-846-140301
Appendix A: REFERENCES
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140303
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140304
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140305
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140306
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140307
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140308
Appendix A: REFERENCES (Cont) - TM-11-5895-846-140309
Appendix B: MAINTENANCE ALLOCATION
Tool or Test Equipment Requirements
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140313
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140314
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140315
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140316
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140317
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140318
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140319
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140320
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140321
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140322
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140323
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140324
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140325
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140326
SECTION II MAINTENANCE ALLOCATION CHART FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140327
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140329
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140330
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140331
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140332
SECTION III TOOL AND TEST EQUIPMENT REQUIREMENTS FOR SATELLITE COMMUNICATIONS TERMINAL AN/TSC-86 (Cont) - TM-11-5895-846-140333
SECTION IV. REMARKS
Appendix C: RECEIVE FIELD ALIGNMENT (AS-3199)
Figure C-1. Low Noise Amplifier, Gain/Slope Adjustment Diagram.
Low Noise Gain/Slope Adjustment
Table C-1 LNA Response Adjustment
Figure C-2. LNA Adjustment Locations
Overall Receiver Gain.
Figure C-4. LNA, Overall Receiver Gain Calibration Diagram.
Overall Receiver Gain. (cont)
Appendix D: STRAPPING REQUIREMENTS FOR COMMUNICATIONS SUBSYSTEM
INDEX
INDEX (Cont) - TM-11-5895-846-140345
INDEX (Cont) - TM-11-5895-846-140346
INDEX (Cont) - TM-11-5895-846-140347
INDEX (Cont) - TM-11-5895-846-140348
INDEX (Cont) - TM-11-5895-846-140349
Figure FO-1. RSS System Fault, Troubleshooting Chart.
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 1 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 2 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 3 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 4 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 5 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 6 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 7 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 8 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 9 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 10 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 11 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 12 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 13 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 14 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 15 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 16 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 17 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 18 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 19 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 20 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 21 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 22 of 23)
Figure FO-2. CSS System Fault, Troubleshooting Chart (Sheet 23 of 23)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 1 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 2 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 3 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 4 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 5 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 6 of 7)
Figure FO-3. Antenna Control Fault, Troubleshooting Chart (Sheet 7 of 7)
Figure FO-4. AN/TSC-86, Functional Block Diagram
Figure FO-5. Power Pallet, Schematic Wiring Diagram
Figure FO-6. Power Distribution Panel, Schematic Wiring Diagram (Sheet 1 of 2)
Figure FO-6. Power Distribution Panel, Schematic Wiring Diagram (Sheet 2 of 2)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 1 of 4)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 2 of 4)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 3 of 4)
Figure FO-7. AN/TSC-86, Interconnection Wiring Diagram (Sheet 4 of 4)
Figure FO-8. EMI Filter, Schematic Wiring Diagram
Figure FO-9. Alarm Monitor Power Supply Test Fixture, Schematic Diagram
Figure FO-10. Alarm Monitor Power Supply Test Fixture Top Chassis Layout.
Figure FO-11. Alarm Monitor Power Supply Test Fixture, Bottom Chassis Layout.
Figure FO-12. Alarm monitor Supply Test Fixture, Top Chassis Marking.
Figure FO-13. Alarm Monitor power Supply Test Fixture, Bottom Chassis Markings.
Figure FO-14. Alarm Monitor Power Supply Test Fixture, Hinge Assembly.
Figure FO-15. Alarm Monitor Fault/Safety Gate Test Fixture, Schematic Diagram
Figure FO-16. Alarm Monitor Fault/Safety Gate Test Fixture, Chassis Layout
Figure FO-17. Alarm Monitor Fault/Safety Gate Test Fixture Chassis Markings
Figure FO-18. Alarm Monitor Power Supply, Schematic Diagram.
Figure FO-19. Alarm Monitor Fault/Safety Gate, Logic Diagram (Sheet 1of 3).
Figure FO-19. Alarm Monitor Fault/Safety Gate, Logic Diagram (Sheet 2 of 3).
Figure FO-19. Alarm Monitor Fault/Safety Gate, Logic Diagram (Sheet 3 of 3).
Figure FO-20. Alarm Monitor, Schematic Wiring Diagram
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 1 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 2 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 3 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 4 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 5 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 6 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 7 of 12).
oFigure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 8 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 9 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 10 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 11 of 12).
Figure FO-21. Radio Subsystem, Interconnection Diagram (Sheet 12 of 12).
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 1 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 2 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 3 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 4 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 5 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 6 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 7 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 8 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 9 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 10 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 11 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 12 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 13 of 14)
Figure FO-22. Radio Subsystem, Interconnection Diagram (Sheet 14 of 14)
TM-11-5895-846-14 Satelite Communications Terminnal AN/TSC-86 (NSN 5895-01-083-6891) Manual
